For further assistance, you can find official documentation on the The Caravan Warehouse or contact the manufacturer, for winter? Caraflo V200 Shower Mixer Tap Thermostatic Chrome
The is the industry standard for modern static caravans, holiday homes, and specialty shower pods. Manufactured by Carafax , this genuine brass-bodied valve replaces the older V100 model. It is widely used by major brands like Swift, Willerby, ABI, Victory, and Delta . caraflo v200 shower instructions
Because it is installed in leisure environments prone to freezing winter temperatures, knowing how to install, operate, and properly drain this unit is vital. Technical Specifications & Verification For further assistance, you can find official documentation
Operating the Caraflo V200 is highly intuitive, featuring separate controls for water flow volume and temperature regulation: It is widely used by major brands like
| | Possible Cause | Suggested Remedy | |-------------|--------------------|----------------------| | No water flow | Inlet supplies reversed (hot on cold, cold on hot) | Check and correct pipe connections | | | Filters or strainers blocked | Clean the filters (see “Maintenance” section) | | | No hot water reaching the mixer | Check water heater operation | | | Water supply isolated | Ensure mains feed taps are fully open | | Low or fluctuating flow | Kinked or damaged shower hose | Inspect and replace hose if necessary | | | Blocked filters | Clean the inlet filters as described above | | | Low system pressure | Verify pressure meets requirements (see below) | | Temperature too hot | Cold water supply failure (fail‑safe should shut off) | Immediately turn off flow . Check cold supply. If problem persists, replace thermostatic cartridge. | | | Thermostat incorrectly adjusted | Adjust internal temperature setting | | | Hot water supply exceeds 65°C | Check water heater settings – maximum allowed is 65°C | | Temperature too cold | Hot water supply too low (below 55°C) | Check water heater – minimum required is 55°C | | | Thermostat incorrectly adjusted | Adjust internal temperature setting | | | Pressure imbalance between hot and cold supplies | Install pressure balancing device or check system design | | Leak from the valve body | Worn O‑rings or seals | Replace damaged seals. Use genuine Caraflo parts. | | | Mixer not tightly seated on tails | Remove, clean, and re‑tighten grub screws | | Leak from shower head connection | Loose or damaged hose washer | Replace the washer or tighten the connection | | Water runs cold when flow is turned back on during shower | Normal thermostatic behaviour | Allow a few seconds for the valve to recover to set temperature | | | Thermostatic cartridge sluggish | Consider replacing the cartridge |
: A standard kit includes brass threaded tails, chrome back plates, an instruction manual, and a dedicated drain-down key Static Caravan Spares Operational Guidelines Temperature Range
For maximum protection during prolonged freezing periods or storage, the manufacturer suggests an additional step beyond the standard drain-down.